4g61t.org

Specializing in the 3g CSM
It is currently Sat Nov 18, 2017 8:01 pm

All times are UTC-05:00




Post new topic  Reply to topic  [ 7 posts ] 
Author Message
PostPosted: Tue Oct 21, 2003 8:42 am 
Here's a list of things that need to be changed right away. These aren't optional. Ignoring these items will definitely leave you stranded one day.

The timing belt - Unless you have a record of it being changed recently, change it now.

The ECU Capacitors - Again, unless you know they've been changed, you really need to change them. The cost of changing them is like 1/100 of buying a replacement ecu.



Things that are a good idea to replace. Items marked with a * can be replaced with upgraded parts.

- Spark Plugs
- Spark Plug Wires *
- Fuel Filter
- Air Filter *
- BISS O-ring
- tranny fluid
- engine oil
- radiator fluid
- tie rod ends
- ball joints
- wheel bearings
- all rubber parts (hoses, bushings)


Last edited by Guest on Tue Oct 21, 2003 9:35 am, edited 1 time in total.

Top
   
 Post subject:
PostPosted: Tue Oct 21, 2003 8:48 am 
Guys add to this list. I want to stick this into the archives.


Top
   
 Post subject:
PostPosted: Tue Oct 21, 2003 9:16 am 
Offline
Nobody Important
User avatar

Joined: Fri Jun 28, 2002 2:19 pm
Posts: 1992
Location: Rochester, NY
Don't forget to change the oil in both the engine and tranny. Coolant is a good idea too.

As with any car, check the steering/suspension too.
  • Jack up one of the front wheels so it is off the ground. (Insert obvious safety disclaimer here)

    Sit on the side of the car facing it and grab the top and bottom of the wheel and try to pull the top towards you while pushing the bottom away (and vice versa). If it wiggles, you need new ball joints.

    Now grab the front and back side of the tire and try again. If it wiggles back and forth you need new tie rod ends. Now the exception with this one is if you are really trying hard to move it you will be flexing the tire on the other side of the car so you will get a little bit of wiggle. You are mainly looking for "slop" in the steering.

    Repeat on the other side.
One more thing, if it is made of rubber INSPECT IT. Coolant lines, Intake lines, CV Joint boots etc.

It doesn't hurt to replace things to get it all at a known state (well, it can hurt the wallet and sometimes the knuckles :))

-paul


Top
   
 Post subject:
PostPosted: Tue Oct 21, 2003 11:12 am 
Offline
Some call me a god

Joined: Sat Jan 19, 2002 7:00 pm
Posts: 1503
Location: Denton, Tx
don't forget safety items,
brakes,
brake lines for cracks,
change brake fluid if it is black/dark grey, should be almost clear,
headlights/tailights/brake lights

_________________
If speed kills, then i shoulda been dead awhile ago. There is no such thing as "Too Much Power". There is no excuse for a lost race. Do you view the rev limiter as a fun limiter?or as a shift point? And we all know, more boost=more fun.


Top
   
 Post subject:
PostPosted: Tue Oct 21, 2003 2:42 pm 
Offline
CSM Expert
User avatar

Joined: Fri Aug 16, 2002 9:00 am
Posts: 2379
Location: Chantilly, VA
Since I'm getting my engine from a junkyard, I'll be replacing:

- all the gaskets in the engine
- while im in there, checking all the valves and pistons for damage
- compression test the cylinders
- check out the turbo for rubbing/damage/play
- replace accesory belt while replacing timing belt


Top
   
 Post subject:
PostPosted: Tue Oct 21, 2003 10:50 pm 
Offline
Spends Too Much Time Under The Hood

Joined: Wed Jan 29, 2003 12:27 am
Posts: 215
Location: San Jose Focka
i think a leakdown test is more accurate than a compression test. lets you know if either an exhaust valve, intake valve, or rings are bad.

dont forget the balance shaft belt when you do your timing belt. or just install a eliminator kit

_________________
The resurrection begins.
90' Plymouth Laser RS Turbo (donor)
90' Dodge Colt (2.3L 4g63T swap)


Top
   
 Post subject:
PostPosted: Wed Oct 22, 2003 7:42 am 
Offline
Member
User avatar

Joined: Fri Apr 25, 2003 12:30 pm
Posts: 50
Location: San Bernardino, CA
Quote:
don't forget safety items...
..also get Fire Extinguisher. It wont cost that much to keep one in your GT.

_________________
Sonny F. Walukow
1999 Toyota RAV4
1990 Honda Accord
1989 Colt GT (Sold)


Top
   
Display posts from previous:  Sort by  
Post new topic  Reply to topic  [ 7 posts ] 

All times are UTC-05:00


Who is online

Users browsing this forum: No registered users and 2 guests


You cannot post new topics in this forum
You cannot reply to topics in this forum
You cannot edit your posts in this forum
You cannot delete your posts in this forum
You cannot post attachments in this forum

Jump to:  
cron
Powered by phpBB® Forum Software © phpBB Limited